oil fill plug mod to remove plug without removing the winch. u need a ball end allen wrench. for ease to install the plug back in . u need a second allen wrench to loosen with about 1/16 ground. off the end. i use a dedicated oil squirt can with a short hose on the spout. just got done making cooling fins. for my add on power steerin g motor. 1.Front Differential: Mobile 1 Synthetic ATF - 9.3oz/275 ml. Rear Differential: Any or Mobil 1 Gear Oil 75W90 - 7.1oz/ 210ml. ADC (Active Decent Control): Mobil 1 Synthetic ATF - the resi is tiny just fill as needed up to the line. Its all in the owners manual. 2012 850xp eps.AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 11. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (14 to 19 Nm). 12. Clean any residual fluid off the vehicle, and inspect for leaks. 13. Dispose of the used fluid properly at your local ...Transmission fluid replacement for the 2015-2021 RANGER 570 and RANGER CREW 570-4 models. View the written article for this procedure here: https://ranger.po...Sep 21, 2022 · The findings indicate the Polaris AGL, even though it's used in the gear-case; is not a traditional gear lube. It's a version of transmission/hydraulic oil. For these reasons, AMSOIL recommends their Synthetic ATV/UTV Powertrain Fluid in place of both the Polaris AGL and the Demand Drive Fluid. 2022 RZR XP 1000 Premium Ride Command.AGL Fluid (part number 2878069) Drain Pan; Fluid Funnel; Eye Protection; Nitrile Gloves; Shop Rags; For information on tools, read the Tools and Fasteners Guide. Always wear safety glasses and nitrile gloves when servicing your Polaris vehicle. For optimal performance, always use Polaris-recommended fluids as described in your Owner's Manual.May 17, 2024 · AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) or part number 2878069 for 1 gallon (3.78 L). 12. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (19 Nm). 13. Clean any residual fluid off the vehicle and inspect for leaks. 14. Dispose of the used fluid properly.To change the transmission fluid on your model year 2020 and older Sportsman 570, Sportsman 570 Utility or Sportsman Touring 570, follow these steps: 1. Park the vehicle on a flat, level surface. 2. Ensure the vehicle is in PARK and set the parking brake. 3. Place a drain pan underneath the transmission. Placing a rag in the …Polaris ADC fluid has been superceded by Polaris Demand Drive fluid. Mark . 2012 850HO Touring EPS Pearl White Good, fast, cheap.....pick 2! Save Share. ... As i was told at Polaris training. Theres no replacement for ADC oil or AGL. Transmission oil. Save Share. Like. polman500.Dec 4, 2023 · AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 11. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (14 to 19 Nm). 12. Clean any residual fluid off the vehicle, and inspect for leaks. 13. Dispose of the used fluid properly at your local ...I use Klotz snowmobile chaincase oil with graphite, and it seems to be the same stuff. Gear oil is formulated to be a bit "sticky" as manual gear cases don't have oil pump, so the sticky oil carries onto the other gears. So, just my $.02, use Polaris AGL. MrEd and Sprede. O.Polaris ADC fluid has been superceded by Polaris Demand Drive fluid. Mark . 2012 850HO Touring EPS Pearl White Good, fast, cheap.....pick 2! Save Share. ... As i was told at Polaris training. Theres no replacement for ADC oil or AGL. Transmission oil. Save Share. Like. polman500.Polaris PS-4 oil is engineered to keep your RZR, Ranger, Sportsman, or General on the trail. Shop off-road oil, oil change kits, grease, extreme, and lubricants for your UTV or ATV.The capacity is 37 ounces (110 ml). AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 13. Reinstall the transmission fill plug. Torque to14 ft-lbs (19 Nm). 14. Clean any residual fluid off the vehicle. 15. Check for leaks. 16. Dispose of the used fluid properly.#2 · May 3, 2018. What is best is a long debate with no real answers that I can find. A lot of peeps are using Amsoil and swear by it. A JD20c hydraulic oil can be used in front by …AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 12. Reinstall the transmission fill plug. Torque to 14 ft-lbs (19 Nm). 13. Clean any residual oil off of the vehicle. 14. Dispose of the used oil properly. For more information, see your authorized Polaris Dealer.The AGL oil used by Polaris is a unique oil because the transmission configuration requires the oil to have a specific "climb-rate" to oil the upper shafts and gears of the tranny. I can't say there isn't an equivalent, but proceed with caution. Sparks Performance Products Home Page. [email protected]. 661-872-4343.Polaris Oil Change Kit for Specific RANGER, GENERAL, RZR, ACE 900 XC Models With 4 Stroke Engine, Includes 2.5 Quarts PS-4 5W-50 Full Synthetic Oil, 1 Oil Filter, 1 Washer, for UTV SxS ATV - 2879323 4.8 out of 5 stars 3,286The fluid capacity is 29 ounces (850 ml) for 2018-2021 800 TITAN Adventure models, 24 ounces (710 ml) for 2022-2023 800 TITAN Adventure models and 23.6 ounces (700 ml) for ProStar S4 models. AGL Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml). 14. Reinstall the fill plug. Torque to 12 ft-lbs (16 ...AGL Advantage: Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Ran.If you are looking for Polaris Transportation Oil sub, this article will help it analyze the best existing options in the market.Inspect the O-rings on both plugs, and replace if necessary. 10. Reinstall the drain plug, and torque to 12 ft-lbs (16 Nm). 11. Fill the transmission through the fill plug hole with AGL Automatic Gearcase Lubricant and Transmission Fluid until it reaches the bottom threads and begins to spill out. The capacity is 41 fl oz (1200 mL). 12.If you are looking for Polaris Transfers Oil substitutes, this article will help you analyze the best available options included the market.Product Description. Genuine Polaris AGL Synthetic Gearcase and Transmission Fluid 0.95L (1 Quart) . AGL oil is specifically designed for Polaris ATVs, Rangers, RZRs to maintain peak performance better than aftermarket fluids. Only Polaris lubricants are specially developed with our engines to handle the intense conditions and high-performance ...AGL Automatic Gearcase Lubricant and Transmission Fluid | Polaris ... ... .AGL Advantage: Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Ran.the tranny fluid, which is polaris AGL fluid, should be able to be subed with a 75 weight or 80 weight gearcase oil. the hub fluid. have heard of guys running ATF fluid, but i cant confirm it works without damage. its a tough call because the engine oil is the only thing polaris will release about the specs of the oil.Description. AGL Advantage: Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, RANGERs and RZRs to maintain peak performance. The proprietary additive system of AGL is formulated using the latest technology to protect vital transmission components, to last longer, control ...1. Park the vehicle on a flat, level surface, ensure the vehicle is in PARK and set the parking brake. 2. Place a drain pan underneath the transmission drain plug. …To change the front gearcase fluid on your RANGER 1000 or RANGER CREW 1000, follow these steps: 1. Park the vehicle on a flat level surface. 2. Place the vehicle in PARK. 3. Place a drain pan underneath the front gearcase. Tip: Place a rag in the bottom of the drain pan to prevent the splashing of oil. 4.Nov 30, 2023 · 5. Reinstall the fill plug. Torque to 12 ft-lbs (16 Nm). Transmission Fluid Replacement. 1. Remove the fill plug (1) with an 8mm Allen socket. 2. Place a drain pan under the drain plug, located on the bottom of the gearcase (2). Tip: Place a shop towel in the bottom of the pan to prevent splashing of fluid.AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 32 ounces (946 ml). 11. Reinstall the transmission fill plug. Torque to 12 ft-lbs (16 Nm). 12. Before continuing, clean any residual fluid off the vehicle and inspect for leaks. 13. Dispose of the used fluid properly at your local recycling center.MrEd. 5065 posts · Joined 2020. #12 · Sep 13, 2023. I tend to Renew my Amsoil membership for the $16 and buy enough fluids for 3-4 years and let the membership expire again. Last price I paid for the Amsoil engine oil change kits was $27.50, which was lower than Polaris kits with much better quality engine oil.The recommended fluid is AGL Automatic Gearcase Lubricant and Transmission Fluid, part number 2878068 for one quart and part number 2878069 for one gallon. 12. Reinstall the transmission fill plug, and torque to 14 ft-lbs (19 Nm). 13. Clean any residual fluid off the vehicle and inspect for leaks. 14.To change the front gearcase fluid on your model year 2021 and newer Sportsman 450, follow these steps. For optimal performance, always use Polaris recommended fluids as described in your Owner’s Manual. 1. Park the vehicle on a flat, level surface, ensure the vehicle is in PARK and set the parking brake. 2.AGL's extreme pressure additive system provides a lubricating film that reduces friction and protects gear sets from heavy shock loads and wear. AGL's unique light viscosity optimizes cavity flow and provides superior chain and bearing lubrication in all climates and conditions. No other gearcase oil on the market is designed to protect Polaris ...2877606,2873602,2872346. AGL Advantage Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Rangers, RZRs to maintain peak performance better than aftermarket fluids. The proprietary additive system of AGL is formulated using the latest technology to protect vital transmissio.To change the transmission fluid on your model year 2020 and older Sportsman 570, Sportsman 570 Utility or Sportsman Touring 570, follow these steps: 1. Park the vehicle on a flat, level surface. 2. Ensure the vehicle is in PARK and set the parking brake. 3. Place a drain pan underneath the transmission. Placing a rag in the …11. Fill the transmission through the fill plug until the fluid begins to seep out of the fill plug. The capacity is 61 ounces (1800 ml). AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 12. Reinstall the transmission fill plug. Torque to 14 ft-lbs (19 Nm). 13.Oct 26, 2019 · Today Amsoil stipulates a GL-5 gear oil rated at 75W-90 to replace AGL. However, while the cold flow viscosity of such an oil has quite a range, that range starts at 10W and could be as high as 20W (on the motor oil J300 table). Note then the possible range never touches the 0W-5W range AGL reportedly occupies.How to change the rear diff fluid of a Polaris Sportsman. This is a 570 Sportsman but the procedure is the same for most sportsman models.If you want to see...AGL Extreme Full Synthetic Gearcase Lubricant & Transmission Fluid, ORV Transmissions, 2891028, 1 Quart (946mL). Item #: 2891028. Replacement for #:. $24.99 USD.How to change the transmission fluid on your side-by-side2021+ Sportsman 450 Transmission Fluid Replacement ... AGL Transmission Fluid; Ratchet; Shop Rags; Torque ... For optimal performance, always use Polaris ...Change the transmission fluid in a forklift by running the engine until it is warm and placing a pain underneath the forklift. Remove the drain plug from the transmission drain pan...4. Place a drain pan underneath the angle drive housing. Placing a rag in the bottom of the drain pan will help prevent the splashing of fluid. 5. Clean the area around the fill plug. 6. Then remove the fill plug with an 8mm Allen socket and set aside. 7. Next, clean the area around the drain plug.2877606,2873602,2872346. AGL Advantage Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Rangers, RZRs to maintain peak performance better than aftermarket fluids. The proprietary additive system of AGL is formulated using the latest technology to protect vital transmissio.ATV/UTV Oil Change Kits (PK1, PK2, PK3) AMSOIL ATV/UTV Kits combine everything needed to perform an AMSOIL oil change on the most popular Polaris* ATV/UTV models in one convenient package. The AMSOIL ATV/UTV Kits include the following: • 2 or 2.5 quarts (depending on the kit) of 5W-50 Synthetic ATV/UTV Motor Oil (AUV50) • 1 oil filterFill the gearcase through the fill plug hole until fluid reaches the bottom threads and begins to spill out. AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) or part number 2878069 for 1 gallon (3.78 L). 12. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (19 Nm). 13.When changing the oil on your Polaris RZR 170, always wear safety glasses and nitrile gloves. Always check and change the oil at the intervals outlined in the Periodic Maintenance Chart in your Owner's Manual . To change the oil and filter on your RZR 170, do the following: 1. Position the vehicle on a level surface in a well-ventilated area. 2.1. Park the vehicle on a flat level surface. 2. Place the vehicle in park. 3. Place a drain pan underneath the transmission drain plug. 4. Clean the area around the …3. Set the parking brake. 4. Place a drain pan underneath the front gearcase drain plug. Tip: Place a rag in the bottom of the drain pan to prevent the splashing of fluid. 5. Clean the area around the fill plug in the right front wheel well. 6. Using an 8mm Allen socket, remove the front gearcase fill plug.The fluid capacity is 41 ounces (1,200 ml). AGL Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 12. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (14-19 Nm). 13. Clean any residual oil off the vehicle and inspect for leaks. 14.Clean the area around the fill plug on the back of the transmission. 4. Remove the fill plug with an 8mm Allen socket and set aside. 5. Move underneath the vehicle and locate the drain plug through the hole in the skid plate. 6. Clean the area around the drain plug. 7. Remove the drain plug with an 8mm Allen socket, and allow the fluid to drain ...AMSOIL says their synthetic chaincase & gear oil is a replacement for the AGL. P. Panzerman. Joined Dec 16, 2006 Messages 4,262 Location Port Orange, Florida. May 30, 2014 ... The gear oil AGL is not real fussy and the Polaris Transmissions are about indestructible. About any motor oil will work in there, although the lighter the better. ...The fluid capacity is 34 ounces (1,000 ml). AGL Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 11. Reinstall both fill plugs. Torque to 12 ft-lbs (16.3 Nm). 12. Clean any residual fluid off the vehicle and inspect for leaks. 13.What brand oil, other than polaris, are you using to change the front and rear gear case oil, as well as, transmission. ... I run Mobil 1 10w-30 with fram oil filter but run AGL in gearcase of 2001 500 ho. I just run standard gearlube in front diff and tranny fluid in hubs of my old one.The capacity is 24 ounces (710 ml). AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 12. Reinstall the fill plug. Torque to 40 to 50 ft-lbs (54 to 68 Nm). 13. Clean any residual fluid off the vehicle and inspect for leaks. 14. Dispose of the used fluid properly.9 posts · Joined 2013. #1 · Jul 28, 2014. I went into the Polaris dealer and asked for front gear case fluid and transmission fluid for an 04 Sportsman. The sold me a qt. of angle drive fluid and Demand drive fuild. Now looking in my repair manual it tells me fill it with angle drive fluid early model o4 and to use Demand drive fluid on the ...Replacing a vehicle’s antifreeze involves draining the old fluid using the drain valve at the bottom of the radiator and replacing it with new antifreeze. The antifreeze mixture sh...The recommended fluid is AGL Gearcase Lubricant & Transmission Fluid, part number 2878068 for 12 quarts. 5. Reinstall the fill plug. Torque to 12 ft-lbs (16 Nm) ...We will email a $5 Birthday Gift to you before your special day. To qualify, you must become a Preferred Customer and update your birthday month at least 14 days before your birthday month. Your birthdate can be updated through your My Rewards page or by phone. You don't have to share your exact birthday with us, we'll celebrate the entire ...Buy Polaris PS-4 Full Service Oil Change Kit with Filter AGL Demand Drive RZR Pro XP Turbo S R XP 4 2520799: Engine Oil ... This item can be returned in its original condition for a full refund or replacement within 30 days of receipt. You may receive a partial or no refund on used, damaged or materially different returns. Read full return policy.Make sure the elevated vehicle is level. Remove the fill plug . If the fluid level is not at the bottom edge of the fill hole, add the recommended fluid to bring the level to the bottom edge of the fill hole. Use a syringe to add the fluid. If a syringe is not available, use a funnel and tube to add the fluid. Reinstall the fill plug.AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 32 ounces (946 ml). 11. Reinstall the transmission fill plug. Torque to 12 ft-lbs (16 Nm). 12. Before continuing, clean any residual fluid off the vehicle and inspect for leaks. 13. Dispose of the used fluid properly at your local recycling center.Jul 14, 2021 · Polaris AGL has been tested. It’s alleged to be roughly 0W-5W engine /20-30 (crankcase) oil, or what in gear oil would be roughly 70W-75. 5W engine oil is roughly analogous to GL-3 diff fluid and was used in low power applications in the past. Long superseded, but it has precedent. AGL is a marketed as a “full synthetic”.Fill the gearcase through the fill plug hole until fluid reaches the bottom threads and begins to spill out. The fluid capacity of the gearcase is 44 ounces (1,300 milliliters). AGL Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 12.To change the angle drive fluid on your model year 2019 and older Slingshot, follow these steps: 1. Park the vehicle on a flat, level surface, and ensure the parking brake is set. 2. Safely elevate the vehicle to gain access to the drain plug located on the bottom of the angle drive housing. Reference your Owner's Manual for proper lifting ...i have a 2005 polaris sportmsn 700 and it take 3 different fluids for the gear cases including trans. For front it takes drive demand fluid, trans takes agl, rear takes angle drive. Its kinda a pain in the ass can i just use one fluid for all 3 gear cases? I would think something on the thicker side but i dont know shit about oilPolaris is a name synonymous with powersports — just head to any of the hundreds of snowmobile trails in Wisconsin, Minnesota or other sufficiently wintry place for evidence. Now, ...Buy all of the drive system fluids you’ll need to keep your transmission healthy: http://bit.ly/polaris-sportsman-850-drive-fluidsLearn how to change the tra...AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 32 ounces (946 ml). 11. Reinstall the transmission fill plug. Torque to 12 ft-lbs (16 Nm). 12. Before continuing, clean any residual fluid off the vehicle and inspect for leaks. 13. Dispose of the used fluid properly at your local recycling center.The recommended fluid is AGL Gearcase Lubricant & Transmission Fluid, part number 2878068 for 12 quarts, part number 2878069 for 4 gallons. ... Transmission Fluid Replacement 1. Remove the fill plug (1) with an 8mm Allen socket. 2. Place a drain pan under the drain plug, located on the bottom of the gearcase (2). Tip: Place a shop towel in the ...AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 32 ounces (946 ml). 13. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (19 Nm). 14. Clean any residual fluid off the vehicle and inspect for leaks. 15. Dispose of the used fluid properly. For more information, see your authorized Polaris Dealer.Tip: Placing a rag in the bottom of the drain pan will help prevent the splashing of fluid. 3. Clean the area around the fill plug in the right front wheel well. 4. Using an 8mm Allen socket, remove the front gearcase fill plug and set aside. Tip: A long ball Allen with a 6-inch extension will aid in fill plug access.Buy Polaris AGL fluid here: https://www.partzilla.com/product/polaris/2878068?utm_source=youtube&utm_medium=video&utm_campaign=description_atfLearn how to pe...One bottle of Polaris Demand Drive will last the average mileage rider between 2-4 years, using 8 ounces per fluid change. I spent more $ for 1 beer at an Angels baseball game last week than the bottle of Polarus fluid. 2 Rzr's since 2012 and several friends and not a single front different issue using the Demand Drive fluid.AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) or part number 2878069 for 1 gallon (3.78 L). 12. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (19 Nm). 13. Clean any residual fluid off the vehicle and inspect for leaks. 14. Dispose of the used fluid properly.Amsoil does recommend it as a replacement for the Polaris AGL fluid. It is not super thick like gear oil. The viscosity is similar to 10w30 motor oil, but it has extra EP additives. kballowe. Joined Oct 26, 2005 Messages 1,147 Location East Central Missouri. May 13, 2018 #5Check the fluid level. 4. Add the recommended fluid to the bottom of the fill plug hole, if necessary. Do not overfill. The recommended fluid is AGL Gearcase Lubricant & Transmission Fluid, part number 2878068 for 12 quarts, part number 2878069 for 4 gallons. See your dealer to order the fluid. 5. Reinstall the fill plug. Torque to 12 ft-lbs ... The recommended fluid is Polaris AGL Fluid, part number 2878068 for one quart or part number 28
This item can be returned in its original condition for a full refund or replacement within 30 days of receipt. You may receive a partial or no refund on used, damaged or materially different returns. Read full return policy ... -2 Bottles of Polaris AGL Synthetic Gear Lube 32 oz. for the transmission -1 Bottle of Polaris Demand Drive Fluid 32 ...Angle Drive Differential Fluid, 2889280, 1 Quart. Item #: 2889280. $19.99 USD. or 4 payments. of on orders up to. on orders over $35 with ⓘ. (0) Write a review. Quantity:the tranny fluid, which is polaris AGL fluid, should be able to be subed with a 75 weight or 80 weight gearcase oil. the hub fluid. have heard of guys running ATF fluid, but i cant confirm it works without damage. its a tough call because the engine oil is the only thing polaris will release about the specs of the oil.Front Differential: Mobile 1 Synthetic ATF - 9.3oz/275 ml. Rear Differential: Any or Mobil 1 Gear Oil 75W90 - 7.1oz/ 210ml. ADC (Active Decent Control): Mobil 1 Synthetic ATF - the resi is tiny just fill as needed up to the line. Its all in the owners manual. 2012 850xp eps.The best replacement for AGL fluid is new AGL fluid. Use the real deal, it doesn't take much.The recommended fluid is AGL Automatic Gearcase Lubricant and Transmission Fluid, part number 2878068 for one quart and part number 2878069 for one gallon. 12. Reinstall the transmission fill plug, and torque to 14 ft-lbs (19 Nm). 13. Clean any residual fluid off the vehicle and inspect for leaks. 14.AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) or part number 2878069 for 1 gallon (3.78 L). 13. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (14-19 Nm). 14. Clean any residual fluid off the vehicle and inspect for leaks. 15. Dispose of the used fluid properly.Fill the transmission through the fill plug hole until fluid reaches the bottom threads and begins to spill out. The capacity is 32 ounces (946 ml). AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 32 ounces (946 ml). 11. Reinstall the transmission fill plug. Torque to 12 ft-lbs (16 Nm). 12.Yes. p5200 and lateburd. Like. lateburd. 25406 posts · Joined 2014. #15 · May 3, 2023. Tractor transmission oil is an excellent substitute also, in fact a multi weight JASO rated engine oil will work as well since it is formulated to lubricate power plants that run the clutch and transmission in the same oil as the engine.AGL and Demand Drive Fluid Quarts Polaris 2878068 2877922. 4.8 out of 5 stars. 1,384. 200+ bought in past month. ... Polaris UTV Replacement Air Filter for Specific Polaris RZR Models, High Performance, OEM Part, Easy Install, For UTV Maintenance and Engine Protection - 1241084.Jun 4, 2014 · I haven't seen anyone saying use 5W-20 for gear oil, but it works fine as an AGL replacement, since AGL is a very thin lubricant, like 5W-20, and lets face it the Polaris trans isn't very high tech. 2016 570 RZR EPS Trail with EBS and Turf mode. Sunset Red. F+R windshields.This item: 2014-2021 Polaris Sportsman 570 OEM Complete Service Kit POL40. +. Slippery Pete Fluid Pump for Gallon Bottles and Wide Mouth Quart Bottles (Not for Standard Quart Bottles) - Transfer Gear Oil, Transmission and Differential Fluid, Antifreeze with This 30cc Hand Pump. One of these items ships sooner than the other.Scrappy507. 1783 posts · Joined 2020. #10 · Dec 23, 2021. I used to use just the usual cheapest high mileage 10-30 oil but I use rotella t6 and t5 diesel oil. 5w-40 for the Polaris, 15w-40 for machines with joined transmissions, and 10w-30 in the mowers. I'm 16, believe it or not.AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 32 ounces (946 ml). 11. Reinstall the transmission fill plug. Torque to 12 ft-lbs (16 Nm). 12. Before continuing, clean any residual fluid off the vehicle and inspect for leaks. 13. Dispose of the used fluid properly at your local recycling center.I'd appreciate some assistance identifying a good reasonably priced alternative to Polaris AGL Gearcase Lubricant and Transmission Fluid for the main gearcase (combined diff/trans). I've seen references to the following, among others: Amsoil Synthetic Chaincase and Gear Oil. Pennzoil Synchromesh Manual Transmission Fluid. 5w20 Synthetic Motor Oil.Replace if necessary. 10. Reinstall the drain plug. Torque to 8 ft-lbs (11 Nm). 11. Fill the transmission through the fill plug hole until fluid reaches the bottom threads and begins to spill out. The capacity is 4 to 5 ounces (150 mL). AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml). 12.AGL Automatic Gearcase Lubricant and Transmission Fluid | Polaris ... ... .Transmission fluid replacement for the 2015-2021 RANGER 570 and RANGER CREW 570-4 models. View the written article for this procedure here: https://ranger.po...4. Place a drain pan underneath the angle drive housing. Placing a rag in the bottom of the drain pan will help prevent the splashing of fluid. 5. Clean the area around the fill plug. 6. Then remove the fill plug with an 8mm Allen socket and set aside. 7. Next, clean the area around the drain plug.turbofiat124 Discussion starter. 168 posts · Joined 2017. #9 · Apr 20, 2017. Well I stopped by Autozone yesterday and discovered a quart of Havoline 75W90 Synthetic is $14 a bottle. So there is really no cost savings advantage. The Polaris oil is $19 a quart. So now I am wondering if I can use GL-1 90 weight oil.Today Amsoil stipulates a GL-5 gear oil rated at 75W-90 to replace AGL. However, while the cold flow viscosity of such an oil has quite a range, that range starts at 10W and could be as high as 20W (on the motor oil J300 table). Note then the possible range never touches the 0W-5W range AGL reportedly occupies.7. Before continuing, clean any dirt or debris from the fill and drain plugs. 8. Inspect the O-rings on both plugs and replace if necessary. 9. Reinstall the drain plug. Torque to 11 ft-lbs (26 Nm). 10. Fill the gearcase through the fill plug hole until fluid reaches the bottom threads and begins to spill out.The fluid capacity is 34 ounces (1,000 ml). AGL Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 11. Reinstall both fill plugs. Torque to 12 ft-lbs (16.3 Nm). 12. Clean any residual fluid off the vehicle and inspect for leaks. 13.AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 11. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (14 to 19 Nm). 12. Clean any residual fluid off the vehicle, and inspect for leaks. 13. Dispose of the used fluid properly at your local ...Check the fluid level. 4. Add the recommended fluid to the bottom of the fill plug hole, if necessary. Do not overfill. The recommended fluid is AGL Gearcase Lubricant & Transmission Fluid, part number 2878068 for 12 quarts, part number 2878069 for 1 gallon. 5. Reinstall the fill plug. Torque to 12 ft-lbs (16 Nm). Transmission Fluid Replacement 1.Mar 11, 2024 · AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 32 ounces (946 ml). 12. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (19 Nm). 13. Clean any residual fluid off the vehicle and inspect for leaks. 14. Finally, dispose of the used fluid properly at your local recycling center.Motor gets Rotella T6 or any good Synthetic racing or diesel oil in 0W40 or 5W40 or 5W50. Transmission gets Synthetic Chaincase oil. Motor oil doesn't have the anti-foaming additives and ATF isn't full synthetic at a reasonable price. 2012 Green Sportsman 500 HO. Polaris Front 2878671 & Rear 2878672 rack extenders.AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 32 ounces (946 ml). 11. Reinstall the transmission fill plug. Torque to 12 ft-lbs (16 Nm). 12. Before continuing, clean any residual fluid off the vehicle and inspect for leaks. 13. Dispose of the used fluid properly at your local recycling center.One quart of Demand Drive does almost four oil changes, which is very cheap maintenance. I change the gearcase and engine at 40 hours. I use Polaris AGL in the gear case. Some people opt for 75/90 or other high-end gear oils, but whatever else you use instead of Polaris AGL, be sure your gear oil has the additive for limited slip differentials.Sep 21, 2022 · The findings indicate the Polaris AGL, even though it's used in the gear-case; is not a traditional gear lube. It's a version of transmission/hydraulic oil. For these reasons, AMSOIL recommends their Synthetic ATV/UTV Powertrain Fluid in place of both the Polaris AGL and the Demand Drive Fluid. 2022 RZR XP 1000 Premium Ride Command.RBC Capital analyst Sean Dodge maintained a Buy rating on Agilon Health (AGL – Research Report) on March 1 and set a price target of $33.0... RBC Capital analyst Sean Dodge m...Hello everyone, I need clarification if anyone can help. Concerning the front and rear gearcase oil, I am getting conflicting information. I did my 25hour maintenance myself on my 2012 Ranger 4x4. My Polaris dealer gave me oil and "AGL Plus" for my front and rear gearcases. So, I put it in both locations.Remove the fill plug with an 8mm Allen socket and set aside. 5. Move underneath the vehicle and locate the drain plug through the hole in the skid plate. 6. Clean the area around the drain plug. 7. Remove the drain plug with an 8mm Allen socket, and allow the fluid to drain completely. 8.AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 11. Reinstall the transmission fill plug. Torque to 14 ft-lbs (19 Nm). 12. Clean any residual fluid off the vehicle, and inspect for leaks. 13. Finally, dispose of the used fluid properly at your local ...Jan 28, 2022 ... In this video I show how to replace fluids for front differential, transmission, rear differential and do a oil change on engine.Would the John Deere low viscosity hygard hydraulic/transmission oil work as a replacement for polaris AGL oil in a ranger-900 transmission. I know it's used as a replacement in the front differential. thanks . Save Share. ... but still a bargain when compared to getting ripped off on polaris oil. Self proclaimed leader of the"570 One Lung Army"Nov 29, 2021 ... In this video I show how to change drivetrain fluids in a RZR 800. This works for all Rzr 800 models including the S from 2008-2014.Buy Polaris AGL fluid here: https://www.partzilla.com/product/polaris/2878068?utm_source=youtube&utm_medium=video&utm_campaign=description_atfLearn how to pe...It is only used in the reardiff' of Rangers with divorced (separate) tranny and rear diff' ('09 and earlier models). Any units with the 1 piece tranny and rear diff' (RZR's included) will use AGL, which is closer to the viscosity of automotive ATF. That is the wrong fluid change kit for your machine. The kit that includes angle drive fluid is ...A full synthetic substitute for both Polaris Demand Drive Fluid and Polaris AGL Synthetic Gearcase and Transmission Fluid. 1-800-748-5781 "Serving you from 13 warehouses across North America ... Does not replace Polaris Angle Drive Fluid. Not suitable for use in API GL-5 applications.May 6, 2024 · AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 12. Reinstall the transmission fill plug. Torque to 14 ft-lbs (19 Nm). 13. Clean any residual oil off of the vehicle. 14. Dispose of the used oil properly. For more information, see your authorized Polaris Dealer.Fill the gearcase through the fill plug hole until fluid reaches the bottom threads and begins to spill out. AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) or part number 2878069 for 1 gallon (3.78 L). 12. Reinstall the transmission fill plug. Torque to 10 to 14 ft-lbs (19 Nm). 13.Polaris AGL has been tested. It's alleged to be roughly 0W-5W engine /20-30 (crankcase) oil, or what in gear oil would be roughly 70W-75. 5W engine oil is roughly analogous to GL-3 diff fluid and was used in low power applications in the past. Long superseded, but it has precedent. AGL is a marketed as a "full synthetic".United's LAX Polaris Lounge begins welcoming flyers this Saturday, January 12. If you've seen one Polaris Lounge, you've seen them all — with each preview event, I've been getting ...Clean any residual oil off the vehicle and inspect for leaks. 15. Dispose of the used oil properly. For more information, see your authorized Polaris Dealer.What is the best replacement for AGL fluid. Jump to Latest Follow 21 - 24 of 24 Posts. 1 2. lateburd · Administrator ... 2017 Polaris 450 HO Sportsman Sage Green Super ATV EZ Steer, Quad Logic Battery Relocation Kit, Duracell Ultra14AH-BS 220 cca battery, Quad Logic 2" Receiver Keep an empty quart oil bottle, stand it up and let it drain as much as possible. Once emp